Amerigo International
Cab
- Upgraded cab - leather & wood trim, additional insulation
- SS fire extinguisher at floor on left side of driver seat
- Seats - adjustable air suspension front
- Cab rear suspension air bag type
- Power windows & doors w/remote control
- Full gauges & instrumentation
- Cobra CB radio
- Alpine CDA-9857 AM FM XM CD Ipod stereo system
- GPS – Garmin 7500 w/rear view camera and weather fax
Chassis
- International 7400 4x4
- Extended cab - Overall length – 372”, width – 98”, height – 144”
- GVWR – 33,000 lb, GCVWR - 80,000 lb
- Wheelbase – 213” (5410 mm), cab-to-axle – 112”, axle-to-frame – 75”
- Frame rails – heat treated alloy steel 120,000 lb psi, 10.866” X 3.622” X 0.433” (276mm X 92mm X 11.1mm)
- DT570 50-state, 310 hp, 950 lb-ft torque @ 1200 rpm, #2 bell housing
- 8 mpg @ 60 mph
- Chassis batteries – 2 X 210 ah AGM marine
- Supplemental alternator – 90a with I-U charging regulator for body
- Engine block heater – Phillips 120v/1250w, located below driver’s door
- Air compressor – Bendix TU-FLO 550, 13.2 cf quick connects front and rear
- Allison 3000 RDS P close ratio, 6-speed w/overdrive
- Transfer case – Meritor T-4210, 2-speed, 10,000 lb w/provision for PTO
- All wheel drive, engageable
- Front axle - Meritor MX-12-120 single reduction, 12,000 lb
- Rear axle - Meritor RS-21-145 single reduction, wide track, 21,000 lb w/driver controlled main locking differential, 200 series wheel ends and ABS gear ratio: 5.13
- Air brake ABS – Bendix antilock brake system, 4-channel
- Front brakes – air cam, S-cam, 16.5” X 5.0” inc 20 sq in MGM long stroke brake chambers
- Rear brakes – air cam 16.5” X 7.0” inc MGM TR3030 long stroke brake chamber and HD spring actuated parking brake
- Exhaust brake – D Logic, electronically activated
- Air dryer – Bendix AD-IP with heater
- Alcoa 22.5” aluminium wheels
- Michellin XZL 445/65R22.5
- Fuel tanks – 2 X 120 gal w/ 9mm skid plates (approximately 2,000 mi range)
- Racor fuel prefilters w/ water separators/heaters
- SS roof rack – in-motion TV antenna, generator cooling system, work lights, and 4 X Hella 2100 HID lights
- SS wire mesh head lights brush & stone guards
- Winches – hydraulic 15,000 lb front & rear w/15 gal reservoir and PTO pump
- Rear bumper - SS fold-down under-ride protection
- Water fording - all breather tubes raised to minimum 5’, positive pressure in generator compartment, sealed storage compartments
- Generator – 8kw Fischer Panda
- Spare - rear mounted w/manual hoist
- Rear rack – manual hoist, adaptable for storage, inflatable boat/outboard, bicycles or motorcycle
Body Unit
Frame assembly
- 3-point kinematic attachment with main and flex mounts for stress-free body coupling to the torsion elastic chassis frame
Body unit construction
- Body dimensions – length 205” X width 98” X height 83”
- Self-supporting UNICAT sandwich panels of fiberglass composite
- Panel connections made by adhesive bond to custom extrusions eliminates metallic heat conduction paths
- Matched thermal coefficients of expansion prevent distortion with changes in temperature
- Wall thickness 2.36" ( 60 mm ) with polyurethane foam insulation, 0.12" ( 3 mm ) FRP outer surface, 0.08" ( 2 mm ) FRP inner surface
- Insulation rating 0.078 btu/ft h degF ( 0.44 W/sqm K )
- Floor panel with integrated welded steel frame and surfaces of fiberglass reinforced polyester
- Teak flooring
Access to body
- Cab-to-body passage – 23” X 32” w/solid & soft panels
- Highly flexible waterproof bellows coupling
- Access to body – hydraulic stairs, 3 control locations
Entrance door and storage compartment doors
- UNICAT - entrance door and storage doors constructed of fiberglass composite panels and frames, 3-point stainless steel safety locks, mosquito net at entry door
- Thickness of doors 2.36" ( 60 mm )
- UNICAT double seals with heavy duty lock
- Stainless steel hinges throughout
- Additional retractable bolts at middle, top and bottom of doors
- Safety cylinder locks all keyed alike
Windows
- Burglar-proof, scratchproof windows with thermal insulated aluminum frames
- Double insulated thermal window glass
- Shutters and mosquito nets
Interior Lay Out
Inner dimensions of the cabin
- Length 200" ( 5080 mm )
- Width 92.9" ( 2360 mm )
- Height 76.8" ( 1950 mm )
Seating area
- Seating area for 2 - 4 people with adjustable swiveling table on pedestal in the front of the cabin
- Seating unit converts to double bed
Bed
- Queen-size bed with suspension, ventilation and comfortable mattress in the rear on pedestal
- Size: 60" x 80" ( 1524 mm x 2032 mm )
Sanitary room
- Sealed fiberglass door to isolate bathroom from living area
- SeaLand ceramic toilet system
- Bath sink – SS w/extra faucet for filtered water, soap dish, towel hooks
- Shower – full size w/adjustable height head, 2X soap/shampoo dishes, SS overhead drying bar
- Medicine cabinet and storage under sink
Kitchen
- Countertop with integrated SS sink
- Collapsible counter top leaf to left of oven/range
- Single handle faucet for warm and cold water, separate faucet for filtered water
- SS soap dispenser, soap dish, towel hooks
- Force10 LPG 3-flame range/oven
- Sanyo 1.2 cubic foot SS microwave oven
- Kitchen cabinets with locking drawers on ball bearings
- Built-in drawer organizers
- Overhead cupboards
- Refrigeration – 2 X 113 liter Kissman w/small freezers, 45 qt freezer and ice maker in luggage compartment
Storage
- Inside storage space in the seating area, kitchen and over bed
- Wardrobe for hanging clothes, pull-out storage boxes
- Large outside storage compartment under the bed pedestal
- Exterior storage - 2 X SS 24” X 24” X 24” 1 X SS 24” X 24” X 48” tool/utility boxes
Workmanship
- All furniture is built to the highest cabinet making standard made of wood core plywood using heavy duty locks and hinges
- Finishes may be specified by customer
Lay out
- Design and color of floor, walls and ceiling may be chosen by customer
- Walls and ceiling are painted with multiple coats
- Upholstery made of fabric, leather or ALCANTARA
Technical equipment
Electrical equipment
- Solar panels – 3 X 123w Sharp
- Control panel for power management and monitoring of liquid levels
- Battery main switch, safety cut-out, residual current breaker
- DC power supplied by (4) AGM batteries bank, automatic regulated alternator and AC automatic I-U charger with cell temperature sensing for shore power hook-up
- Battery capacity: 12V 840Ah
- Shore charge rate: 14V 120A
- Inverter – Xantrex Prosine 12V / 115V, max output 3.0 kW
- Power plugs for 12V DC and 115V AC
Audio-visual system
- Alpine CDA-9857, CD changer, AM FM, XM sat radio, Ipod
- Sharp 21” LCD HDTV/DVD players at bed and dining area
- Brackets and wiring for outside speakers
Lighting
- Low voltage XELOGEN ceiling lights over the table, kitchen, bed and shower
- Lights for outside storage compartment
- Reading lights in bed and seating area
Water supply
- 112 gallons ( 425 liters ) freeze-proof drinking water tanks
- 8 gallons ( 22 liters ) hot water heat-exchanger
- 15 gallons ( 60 liters ) waste water tank
- 25 gallons (100 liters) gray water tank
- All plumbing is insulated to prevent freezing
- Outside shower at rear luggage compartment
- Water filtration system
LPG supply
- 2 x 30 lb. cylinders in sealed compartment
- Quick connect for barbecue at rear luggage compartment
Heating, ventilation and A/C systems
- Webasto diesel powered warm water central heating ( 5 kW )
- Radiant heaters at shower, dining area, and coil under bed
- Anti-frost system
- 2 X 13,500 BTU Penguin A/C roof units
- Maxxfan units above sink and in bath
Alarm system and emergency equipment
- Fire, smoke and carbon monoxide detector/alarm
- Mag-lite flashlight/charger at door
- SS fire extinguisher at door
Options
- BGAN global communications system (voice and data)
- Custom rear rack for inflatable boat, motorcycle, bicycles
- Portable (Spectra “Aquifer”) 6 gph reverse osmosis unit
- Expedition grade first aid kit
- Self extrication kit
- Chassis/motor-specific expedition replacement parts kit
- Generator expedition replacement parts kit
- Emergency outside (DragonMax) lighting
- International water connectors/adaptors and hoses kit
- International electrical adaptors kit
- International propane adaptors kit
- Air fittings and hoses kit
